700 Crew Just Bogs - RangerForums.net - Polaris Ranger Forum
General Discussion Talk about anything here.

 
LinkBack Thread Tools Search this Thread Display Modes
post #1 of 6 Old 05-03-2019, 08:53 AM Thread Starter
Couch Potato
 
Jhog's Avatar
 
Join Date: Apr 2019
Posts: 5
700 Crew Just Bogs

2009 700 EFI Crew Runs great at startup but after 1/4 mile at speed just begins to bog like it's choking itself to death. I have verified compression at 120 on both and fuel pressure stays constant at 40-42 psi at all times. Complete air intake system has been gone through and new filter installed. I have also installed new coil and plug wires. The TPS has been replaced and adjusted properly, no check engine light currently.Also cleaned TBAP sensor and repaired bad spot in harness. Any ideas would be greatly appreciated !!! Also the speedo is in/op but all other function of the display work nicely.
Jhog is offline  
Sponsored Links
Advertisement
 
post #2 of 6 Old 05-06-2019, 05:23 PM Thread Starter
Couch Potato
 
Jhog's Avatar
 
Join Date: Apr 2019
Posts: 5
After no other suggestions i'm considering checking the rocker arm travel to verify that the cam lobes aren't worn. Anyone have the cam specs for this machine ? Otherwise i guess i'll just verify that the exhaust is equal to the intake. The symptoms of this machine seem to duplicate the old 425 and 500 atvs with excessively worn exhaust cam lobe. Also i have been informed that the complete exhaust system was replaced less than a year ago but no mileage documents to verify how many miles or hours ago.
Jhog is offline  
post #3 of 6 Old 05-08-2019, 11:06 AM Thread Starter
Couch Potato
 
Jhog's Avatar
 
Join Date: Apr 2019
Posts: 5
Got the lifters out and inspected camshaft. All good. Trying to think out of the box here, going to pull fuel pump out and check filter. Is it possible that i have correct fuel pressure but not enough volume ??
Jhog is offline  
Sponsored Links
Advertisement
 
post #4 of 6 Old 05-08-2019, 01:58 PM
Gear Grinder
 
rock2100's Avatar
 
Join Date: Feb 2018
Location: South Dakota
Posts: 223
Check the speed sensor on the transmission if it has one. I have a 2019 and I have had the trans speed sensor connection get wet and do just what your describing. The speedo would quit working also
rock2100 is offline  
post #5 of 6 Old 05-09-2019, 11:38 AM Thread Starter
Couch Potato
 
Jhog's Avatar
 
Join Date: Apr 2019
Posts: 5
Great info, thanks. I'll try to get under there tonight or tomarrow and see if i can locate it
Jhog is offline  
post #6 of 6 Old 05-09-2019, 01:08 PM
Paper Boy
 
Quintin's Avatar
 
Join Date: Apr 2019
Posts: 10
The speed sensor is on the right front wheel. They are almost bullet proof. When Polaris starting putting them on the transmission in the 900 there was a lot of problems. Have you had the fuel pressure gauge on while riding and when it starts to bog? The fuel filter can start crumbling and cause bogging. If the unit has been putted around it's possible but not likely the muffler is partly plugged.
Quintin is offline  
Reply

  Lower Navigation
Go Back   RangerForums.net - Polaris Ranger Forum > Polaris Ranger Forum > General Discussion

Thread Tools Search this Thread
Show Printable Version Show Printable Version
Email this Page Email this Page
Search this Thread:

Advanced Search
Display Modes
Linear Mode Linear Mode



Similar Threads
Thread Thread Starter Forum Replies Last Post
2019 Polaris Ranger Crew XP 1000 vs. Can-Am Defender MAX DPS HD10: By the Numbers VS_Goose Announcements & Events 0 04-17-2018 12:04 PM
Crew 700 Knocking help Jordo487 General Discussion 7 04-07-2017 09:54 PM
08 Ranger Crew 700, code 25, will not start Airschatz General Discussion 1 11-12-2016 06:18 AM
570 MS battery replacement Adventure68 Polaris Ranger 570 13 03-19-2016 06:31 AM
570 Crew or 900 Crew? Foregolfdog General Discussion 2 03-09-2016 09:48 PM

Posting Rules  
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome